Recent content by Bigfish95971

  1. B

    Transfer case won't shift

    It is 04
  2. B

    Transfer case won't shift

    After two new coder motors Cardone and the Dorman i put on today I am convinced the shop was wrong and it is likely the TCCM does not seem to be booting up (waking up I heard it called). I turn the key on I get all four lights flashing on the dash switch but nothing will stay on or com on when I...
  3. B

    Transfer case won't shift

    Yes on shift motor. I thought that was what the AC Delco shop here did. They said the Cardone motor I put on was bad and my old was bad too. Wanted to sell me a new Dorman for about 700 more that the 300 I gave them for diagnosis. I put it on my self for 250. nowhere sit. Right now I have...
  4. B

    transfer case won't shift, everything replaced

    Truck would not shift, Got stuck in 2x4 or 4x4 auto. Related everything, some twice. Took it to a shop, they said bad shift motor. Prepacked again, I first put on a Cardone, Second was a Dorman and it is on it now. New, diff solenoid, New dash switch(lights flash with the key but does do...
  5. B

    Transfer case won't shift

    worked fine, Quit working and was stuck in 2x4. then got ***** and was stuck in automatic 4x4, Then back in 2x4 and so on. ended in 4x4 automatic. Changed out swithc, Module, motor, and finally the solenoid to the diff, One at a time. Early on when replaced the control module I tried battery...
  6. B

    "service 4-wheel drive" on dash when key is turned on.

    Sorry been busy hunting. not fixed yet. Got several code I do not remember except they indicated the tccm not communicating. Doing reset right now. Not confident. Is a used TCCM plug and play? I have not read of any programming required on new or used.
  7. B

    "service 4-wheel drive" on dash when key is turned on.

    Service 4x4 light has been comping on for some time. Now it won't switch to anything else, Has stayed and run in 2x4. Lights on switch all flash during key boot up. Fuse good. What is my likely problem, switch, shift motor, wires, other? No codes.
  8. B

    AC Quit

    It is a replacement clutch, but used. So that is a check I have not tried so I might do that. Right now concentrating on getting the Dodge Trani done. Right now I am busy getting ready for a minor surgery on Monday. That will delay me another week of digging into crap under the truck. I...
  9. B

    AC Quit

    At this point I believe everything is working and the relay is sending juice to the Compressor coil, but it is shorting out before reaching he clutch and blowing the fuse. I can try jumping the clutch directly again and see what happens. I also heed to test the wires for a direct short. Was...
  10. B

    AC Quit

    Thank you both of you. I do not believe the control unit needed programming, It seemed to work the same as the old one. Turned everything on. I fixed a loose pin on the buss wire. Still just no clutch engagement. Finally replaced clutch still not go. One time when working on fuse box I...
  11. B

    AC Quit

    I can not pull that code with my little tool. A shop said I had that one. i substituted a heater control unit, no help. I had the schematics. I pulled the control unit and PCM and check that bus wire and pins. The pins looked good but the flat contacts on the in it side looked flattened out...
  12. B

    AC Quit

    Finally got tools and differnt clutch and coil installed. Still no cool and blowing AC fuse. Can a bad pcm blow the fuse? Other ideas?
  13. B

    AC Quit

    I found the dash control to be ok but the pin connections on the Buss wire on both the PCM and dash control contact looked flattened out and I bent them back an I think that fixed that . But I believe I had shorted out the the coil messing with it. Plus I found a bad ground wire on the coil...
  14. B

    AC Quit

    Is the front end shrouds and so on the same on an 03, that looks older?
  15. B

    AC Quit

    I have a 99 that I post on hours daily in 2nd gen sections helping people daily. There is a gentleman now in Germany goes by Ukraineram on the Dodge Cummins Diesel Forum site that. He moved to Germany after the war started. He is building a badass 3500 somewhere in Germany where his company...
See more

Forum statistics

Threads
138,048
Posts
1,997,869
Members
102,989
Latest member
justinakay79

Latest posts

Back
Top