Need help… Crank/no start + Really bad MPG

Disclaimer: Links on this page pointing to Amazon, eBay and other sites may include affiliate code. If you click them and make a purchase, we may earn a small commission.

Rayyy

Full Access Member
Joined
Jun 4, 2020
Posts
299
Reaction score
133
Location
Northern California
2004 Vortec 5.3 4x4

It never, ever starts on first try. Cranks, but no start. However, starts right up on the second attempt every time.

Also, truck seems slightly sluggish. It still pulls at WOT, just seemingly not at 100% power.

MPG is a wopping 8.1MPG (confirmed by calculating manually using an MPG app too)… Even when I cruise around in town below 2,000rpm for the entire tank.

@ idle RPM
STFT 2.3+/-
LTFT +4.7 (bank 1) +6.2(bank 2)

@2500 RPM
STFT -4.7
LTFT +7.8 (both banks)


So far, I’ve replaced the plugs, wires, valve covers, intake air filter, MAF, brakes.

I’ll be adding some additives to the next tank to try to clean the fuel system and injectors, as well as replace the fuel filter.

Wondering if anyone has any idea of what else it could be?
 
Last edited:

Fless

Staff member
Super Moderator
Joined
Apr 2, 2017
Posts
10,246
Reaction score
20,306
Location
Elev 5,280
I would replace the fuel filter and see what the fuel pressure looks like both key-on engine off, and engine running.

^^^ This. Test fuel pressure at the fuel rail. Use the standard KOEO test, as well as when it's running.

Based on your RPO codes you have a non-Flex Fuel LM7 engine.
 

RAMurphy

Bob
Supporting Member
Joined
Oct 5, 2011
Posts
1,113
Reaction score
3,234
Location
S. Maryland
As already been stated. Get a good reading on your fuel pressures and replace that fuel filter. Have you tried to turn the ignition to "on" for a 3-5 seconds (to build up fuel pressure) before cranking to see if that helps your first start. Before replacing my original fuel pump (290K miles), I was having a similar problem during initial start.
 

OR VietVet

Multnomah Falls
Supporting Member
Military
Joined
Oct 8, 2014
Posts
19,067
Reaction score
31,163
Location
Willamette Valley
My girl's 2002 TrailBlazer is going thru that initial crank and no start or long crank before start. 3-5 seconds KOEO and then starts as normal. The problem is very intermittent. Lots of power. I have ran tests and know it is the bleed off of fuel pressure at the pump. Great pressure but bleeds down to about 30 psi in an hour and bleeds more the longer it sets.
 

OR VietVet

Multnomah Falls
Supporting Member
Military
Joined
Oct 8, 2014
Posts
19,067
Reaction score
31,163
Location
Willamette Valley
By the way, I did not just assume the pump was the bleed off. I checked by pinching the fuel return line. I saw very slight clean area at fuel pressure regulator, like a fuel leak, and I replaced with a Genuine GM part.
 
OP
OP
Rayyy

Rayyy

Full Access Member
Joined
Jun 4, 2020
Posts
299
Reaction score
133
Location
Northern California
My girl's 2002 TrailBlazer is going thru that initial crank and no start or long crank before start. 3-5 seconds KOEO and then starts as normal. The problem is very intermittent. Lots of power. I have ran tests and know it is the bleed off of fuel pressure at the pump. Great pressure but bleeds down to about 30 psi in an hour and bleeds more the longer it sets.
How is the MPG?

I don’t believe the 02 had the Average MPG in the cluster… but, there is an app called Fuely, which calculates for you and just requires to input odometer/fuel at each fill up.
 

OR VietVet

Multnomah Falls
Supporting Member
Military
Joined
Oct 8, 2014
Posts
19,067
Reaction score
31,163
Location
Willamette Valley
How is the MPG?

I don’t believe the 02 had the Average MPG in the cluster… but, there is an app called Fuely, which calculates for you and just requires to input odometer/fuel at each fill up.
Not really worried about MPG. It is her around town vehicle, so she has a smaller vehicle to park easier and still carry loads in back. I have my 05 Z71 and she has a 1990 Chevy K2500 ext cab truck with a shell on it. Only has 128k miles on that truck and is as solid a rig as there is out there.
 

Forum statistics

Threads
128,781
Posts
1,805,310
Members
91,760
Latest member
MyCleftNut

Latest posts

Top